• Journal of Inorganic Materials
  • Vol. 38, Issue 10, 1193 (2023)
Songze WU1, Yang ZHOU1、*, Runfeng LI2, Xiaoqian LIU1, Cuiwei LI1, and Zhenying HUANG1
Author Affiliations
  • 11. Research Center of Rail Vehicles Safety Monitoring and Health Management, School of Mechanical and Electronic Control Engineering, Beijing Jiaotong University, Beijing 100044, China
  • 22. State Key Laboratory of Solid Waste Reuse for Building Materials, Beijing Building Materials Academy of Sciences Research, Beijing 100041, China
  • show less
    DOI: 10.15541/jim20230065 Cite this Article
    Songze WU, Yang ZHOU, Runfeng LI, Xiaoqian LIU, Cuiwei LI, Zhenying HUANG. Reaction Sintered Porous Ceramics Using Iron Tailings: Preparation and Properties[J]. Journal of Inorganic Materials, 2023, 38(10): 1193 Copy Citation Text show less

    Abstract

    To expand the utilization of iron tailings, four kinds of porous ceramics were prepared by foam gel-casting with pressureless sintering, foam gel-casting with reactive sintering, and mold forming with reactive sintering using fine-grained high-silicon iron tailings, iron tailings + graphite, and iron tailings + graphite + silicon carbide as raw materials, respectively. DSC-TG and XRD analysis was applied to investigate the sintering process of iron tailings and the carbothermal-reduction reaction between iron tailings and graphite. The four porous ceramics’ porosities, compressive strengths, and thermal conductivities were further analyzed. The results show that the porous ceramics made only from iron tailings possesses high porosity (87.2%), compressive strength (1.37 MPa), and low thermal conductivity (0.036 W/(m·K)), meeting the requirement of thermal insulation material. Silicon carbide porous ceramics with improved thermal conductivity but a slight sacrifice of strength can be fabricated through carbothermal reduction between iron tailings and graphite. Moreover, the compressive strength of silicon carbide porous ceramics can be significantly increased by adding some silicon carbide to the raw materials. The silicon carbide porous ceramics achieved high porosity of 91.6%, high compressive strength of 1.19 MPa and thermal conductivity of 0.31 W/(m·K), which can be a guarantee of a carrier for composite phase change materials or light thermal conductive materials. Compared with foam gel-casting, the mold-forming process can significantly improve the thermal conductivity (1.15 W/(m·K)) of silicon carbide porous ceramics and greatly reduce the cost of raw materials and manufacturing, which is profitable for industrialization.
    Songze WU, Yang ZHOU, Runfeng LI, Xiaoqian LIU, Cuiwei LI, Zhenying HUANG. Reaction Sintered Porous Ceramics Using Iron Tailings: Preparation and Properties[J]. Journal of Inorganic Materials, 2023, 38(10): 1193
    Download Citation